![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/aronson-conveyor_1.jpg\" "\\"aronson-conveyor_1\\"")
<\/p>\n<\/p>\n
I was reminded of the Conveyor Belt for the Dead Sea Works (pictured above) by FASLANYC<\/em>‘s post last week<\/a>, which rightly notes that Israeli landscape architect Shlomo Aronson<\/a> completed a small series of projects in the mid-eighties which prefigured the contemporary interest in landscape infrastructures<\/a>. While the conveyor belt is an obviously sculptural (and beautiful) presence in the Rift Valley landscape, a more important concern for the invisible patterns of the Judean desert ecology drives the architecture of this infrastructure and makes the project significant as a case studio in the ability of an architect to enhance the ecological function of a large-scale infrastructure.<\/p>\n The conveyor belt, at 18 kilometers the third longest in the world (at least at the time of its design), was planned by the Dead Sea Works to convey over a million tons of potash each year from the extraction site (400 meters above sea level) to the Dead Sea Works’ main factory on the banks of the Dead Sea (400 meters below sea level).\u00a0 The belt replaced a \u201ctortuous 39-kilometer truck route where 200 semi-trailers a day loaded with potash once clogged traffic, created a safety hazard, damaged the road, and spewed diesel fumes\u201d.\u00a0 Israel’s Nature Reserves Authority at first opposed the project (which would span the entire South Judean Desert Nature Reserve, \u201cknown for the flora, wildlife, and archaeological sites of its unspoiled canyons and cliffs\u201d), citing the fragility of the desert environment, but later approved it on the condition that the Dead Sea Works employed a landscape architect to design the conveyor belt.<\/p>\n Aronson redrew the planned belt route to avoid building unnecessary earthworks, while lengthening bridges to allow \u201cfree passage for hikers and desert animals\u201d.\u00a0 Bridges, which also replaced earthworks wherever possible, were constructed by cranes perched either on the route of the belt or on previously built sections of the bridge, so as to minimize the impact of construction on the delicate desert ecology.\u00a0 Aronson required all work to be done within a narrow 10-meter construction corridor; this restriction was followed strictly, despite the need to move over a million tons of earth and to construct 12 bridges.\u00a0 The delicate steel bridges and the yellow ochre sheath of the conveyor were selected to simultaneously emphasize the lengthy infrastructure as a significant engineering feat while permitting the belt to complement, rather than overwhelm, the existing landscape.<\/p>\n The conveyor belt, then, at both the local scale (bridges, earthworks, pylons) and the regional scale (the route) was constructed specifically to account for both visible aims (the preservation of the scenic value of the Syrian-African Rift Valley) and invisible aims (the free flow of wildlife, the avoidance of damage to local ecologies).\u00a0 It serves at once as a statement of the scale of human intervention in the Israeli landscape and as a statement of the possibility of designing that intervention so as not to detract from that environmentt, but to augment and emphasize the intrinsic beauty of the pre-existing landscape.<\/p>\n As fascinating and long as the belt is, though, it is a relatively minor infrastructure in comparison to the vast — eighteen miles long — Salt Ponds it feeds its cargo onto the shores of.\u00a0 And those Ponds perhaps present an opportunity for a much more substantial landscape intervention, one which would not merely seek to ameliorate the conditions produced by accepted industrial processes (as Aronson’s conveyor belt does so skillfully), but would look to fundamentally reorganize those processes.\u00a0 This difference of opportunity may serve to effectively highlight the difference between two possible answers to the question FASLANYC<\/em> poses, “what value do landscape\/architects add to the design of infrastructures?”, a question which mammoth<\/em> has previously been concerned with<\/a>.<\/p>\n The Dead Sea Works are a major global chemical producer, supplying in particular potassium — one of the three primary ingredients in chemical fertilizers — to over sixty countries on five continents.\u00a0 An article (part of a larger series entitled “Life from the Dead Sea”, which is worth reading if you’re intrigued by the Dead Sea) at WysInfo<\/em> describes<\/a> the production process:<\/p>\n The potassium in the Dead Sea is… produced at the Dead Sea Works by a process based on selective sedimentation of the non-required minerals in a system of evaporation ponds until the solutions of the desired composition are finally obtained.<\/p>\n For the construction of the ponds a system of dams was built which today encompasses the Israeli sector of the shallow southern basin of the sea, which is now in fact a vast evaporation pond.<\/p>\n At present, the water of the Dead Sea is pumped from the deep northern basin a distance of 400 meters and carried in a canal to the southern basin, into the ponds, where \u2013 through natural evaporation \u2013 the water loses 50% of its initial volume and kitchen salt and calcium chloride crystallize out into a second system of ponds. Here the carnallite, which is the raw material for producing potash, crystallizes and sediments. Potash is an impure form of potassium carbonate (K2<\/sub>CO3<\/sub>) mixed with other potassium salts. Potash has been used since ancient times as a fertilizer and in the manufacture of glass and soap. <\/span><\/p>\n This material is mechanically \u201charvested\u201d from the bottom of the pools and pumped through pipes to the potash plant. Here the carnallite crystals are separated from the stock solution and washed in water to dissolve the magnesium chloride in the solution…<\/p>\n<\/blockquote>\n In order to add value to the relatively cheap raw materials (also including bromine, magnesium, and salt) harvested from the Dead Sea waters in the evaporation ponds, the Dead Sea Works refines the harvested potash into compound fertilizers, a process which multiplies the value of the chemicals ten-fold, but requires combining the Dead Sea potassium with “phosphate-rich sediments [found] to the west of the Dead Sea”, which are brought to the shores of the Salt Ponds on Aronson’s conveyor belt.<\/p>\n This chemical harvest produces a great deal of economic benefit for Israel, providing employment to thousands and being the primary way in which Israel benefits from the mineral wealth of the Dead Sea (which is the largest concentration of accessible mineral within the country’s borders — estimated at 1.9 billion tons of potassium chloride and as much as 44 billion tons of salt), but the continuous diversion of mineral-laden water from the northern basin of the Dead Sea south into the evaporation ponds is exacerbating the already perilous shrinkage of the Sea.<\/p>\n An article in Smithsonian<\/em> magazine from 2005 explains<\/a> the history of the Dead Sea and how it came to enter its current state of rapid decline:<\/p>\n Created by the same shift of tectonic plates that formed the Syrian-African Rift Valley several million years ago, the Dead Sea owes its precarious state to both human and geological factors. Originally part of an ancient, much larger lake that extended to the Sea of Galilee, its outlet to the sea evaporated some 18,000 years ago, leaving a salty residue in a desert basin at the lowest point on earth\u20141,300 feet below sea level. Since then, this body of water, known as the Dead Sea since Greco-Roman times, has maintained its equilibrium through a fragile natural cycle: it gets fresh water from rivers and streams from the mountains that surround it and loses it by evaporation. The evaporation process, combined with its rich salt deposits, account for its extraordinary\u2014up to 33 percent\u2014salinity (compared with the up to 27 percent salinity of Utah\u2019s Great Salt Lake). Until the 1950s, the flow of fresh water equaled the rate of evaporation, and Dead Sea water levels held steady. Then in the 1960s, Israel built an enormous pumping station on the banks of the Sea of Galilee, diverting water from the upper Jordan, the Dead Sea\u2019s prime source, into a pipeline system that supplies water throughout the country. To make matters worse, in the 1970s Jordan and Syria began diverting the Yarmouk, the lower Jordan River\u2019s main tributary.<\/p>\n Since then, the Dead Sea has declined dramatically. It needs an infusion of 160 billion gallons of water annually to maintain its current size; it gets barely 10 percent of that. Some 50 miles long in 1950, the sea is about 30 miles long today. Water levels are falling at an average rate of three feet per year. According to a recent Israeli government study, the rate of evaporation will slow and the Dead Sea will reach equilibrium again in a few decades\u2014but not before losing another third of its present volume.<\/p><\/blockquote>\n Ironically, though the northern basin is imperiled by retreating water levels, posh hotels along the industrialized southern basin of the Dead Sea are besieged<\/a> by rising water levels produced by the deposition of waste salts, which lifts the bed of the southern basin approximately seven inches a year, causing the hotels to surround themselves with sand dikes and plan for a leisure lagoon, cordoned off from the industrial ponds.\u00a0 At the northern end, hotels obviously have the opposite problem: the beach is racing away from their doors, so hotels employ tractors and wagons to ferry tourists from their rooms to the banks of the Sea.\u00a0 The declining overall volume of the Sea is also emptying the surrounding freshwater aquifers, producing over a thousand gaping sinkholes in the past fifteen years, as retreating freshwater dissolves underground salt deposits.\u00a0 Together with increased erosion, the sinkholes have destroyed roads, date palm orchards, and buildings, producing a landscape sufficiently unstable to lead the Israeli government to proclaim a development freeze in the vicinity of the Sea.\u00a0 Complex oasis ecosystems which belie the Sea’s moniker by supporting vibrant communities of flora and fauna, including five hundred million migratory birds who stop at the Dead Sea between Africa and Europe, are similarly threatened.<\/p>\n This environmental and economic catastrophe is by no means solely the result of the industrial processes employed at the Dead Sea Works, but the evaporation ponds do contribute significantly to the draining of the northern basin (by one estimate<\/a>, approximately a quarter of the yearly shrinkage is attributable to the Dead Sea Works).<\/p>\n In a watershed as water-poor as that of the Jordan River, increased conservation alone will not be able to reduce freshwater demands to levels which could reverse the shrinking of the Dead Sea, though there is no doubt that increased conversation is necessary.<\/p>\n Given that reality, a number of serious large-scale engineering proposals to reverse the drainage of the Dead Sea exist<\/a>, including two plans for massive canals linking the Dead Sea to larger waterbodies which could replenish it — the Red Sea to the south and the Mediterranean to the west, as well as the development of mass-scale desalination plants which could supply fresh water to replace that taken from the Jordan and its tributaries, potentially affording the opportunity to let the Jordan run freely into the Dead Sea again.<\/p>\n But perhaps what is needed is not merely a new set of mega-infrastructures, diverting water across deserts from other watersheds (and doing so in a manner which is potentially quite dangerous<\/a>), but a re-configuration of the industrial processes at work in the Dead Sea, a re-shaping of the industrial landscape to create positive feedbacks into biological systems?\u00a0 One might easily believe that the Dead Sea is exactly the sort of industrialized and urbanized “bio-physical system” which Pierre Belanger has argued (PDF<\/a>) can only be understood and dealt with at a watershed-scale:<\/p>\n Endogenous and exogenous processes, such as eutrophication, combined-sewer overflow, sediment contamination, invasive flora, exotic fauna, depleted water reserves, and seasonal floods can no longer be perceived as isolated incidents but rather as a part of a large, constructed hydrological ecology that is entirely and irreversibly connected to the process of urbanization…<\/p><\/blockquote>\n What form a landscape infrastructure for the revitalization of the Dead Sea might take is difficult to say; perhaps the Dead Sea Works might be inspired by their success at producing salt from salt water, and try their hand at separating out the other component in that raw ingredient, augmenting the salt ponds and fertilizer-production facilities on the southern basin with networks of desalinization plants, capitalizing (as the ponds do, through evaporation) on the plentiful solar energy of the Negev to power those plants.\u00a0 Or perhaps, like Orange County, a far-sighted municipality could construct a string of wastewater recycling plants and recharge the freshwater aquifers surrounding the Sea, halting the spread of erosion and sinkholes.\u00a0 Whatever the form, agriculture, industry, wastewater systems, and natural ecologies could be viewed not as competing interests vying over a singular and shrinking water supply, but as necessary components of a single regional urban ecology, with waste flows from one component providing the raw material for the processes of others.<\/p>\n Quotations in this post related to the conveyor belt are derived from both an article, “Desert Conveyance”, which ran in Landscape Architecture in April 1991 and Aronson’s monograph, Making Peace with the Land<\/a>.\u00a0 I’m afraid that I didn’t record which quotations came from which source when I originally took them down several years ago; related to the larger question of the Dead Sea Works, doubts linger about the long-term sustainability of any regional economy based on phosphorous production or application: read Infranet Lab on “peak phosphorous”<\/a> and further background on “peak phosphorous” in this article<\/a> by Melinda Burns (via @bldgblog<\/a>), which includes the suggestion by a scientist that “there\u2019s a whole industry that needs to be invented to capture phosphorus” — perhaps a further clue to what a re-invented Dead Sea Works might look like, as the phosphate waste products of farming, as well as the urban sewage choking the Jordan, could become the raw material for industry and the water wasted by industry the lifeblood of agriculture and a reinvigorated Dead Sea.<\/em><\/p>\n","protected":false},"excerpt":{"rendered":" I was reminded of the Conveyor Belt for the Dead Sea Works (pictured above) by FASLANYC‘s post last week, which rightly notes that Israeli landscape architect Shlomo Aronson completed a small series of projects in the mid-eighties which prefigured the contemporary interest in landscape infrastructures. While the conveyor belt is an obviously sculptural (and beautiful) […]<\/p>\n","protected":false},"author":2,"featured_media":0,"comment_status":"open","ping_status":"open","sticky":false,"template":"","format":"standard","meta":{"footnotes":""},"categories":[15,43,397],"tags":[329,133,851,247,320,332,269,293,328,844],"class_list":["post-1732","post","type-post","status-publish","format-standard","hentry","category-infrastructure","category-landscape-architecture","category-the-expanded-field","tag-dead-sea","tag-hydrology","tag-landscape-architecture","tag-landscape-infrastructures","tag-mining","tag-phosphorus","tag-pierre-belanger","tag-re-industrial","tag-shlomo-aronson","tag-urbanism"],"_links":{"self":[{"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/posts\/1732","targetHints":{"allow":["GET"]}}],"collection":[{"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/posts"}],"about":[{"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/types\/post"}],"author":[{"embeddable":true,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/users\/2"}],"replies":[{"embeddable":true,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/comments?post=1732"}],"version-history":[{"count":21,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/posts\/1732\/revisions"}],"predecessor-version":[{"id":2674,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/posts\/1732\/revisions\/2674"}],"wp:attachment":[{"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/media?parent=1732"}],"wp:term":[{"taxonomy":"category","embeddable":true,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/categories?post=1732"},{"taxonomy":"post_tag","embeddable":true,"href":"http:\/\/m.ammoth.us\/blog\/wp-json\/wp\/v2\/tags?post=1732"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}The origin of the conveyor belt, at the potash extraction site; the belt is highlighted with a faint red line.\u00a0 The belt is easily picked out against the desert topography in satellite imagery<\/a>.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/aronson-conveyor_satellite-1.jpg\" "\\"aronson-conveyor_satellite-1\\"")
<\/p>\nThe conveyor terminates in the Dead Sea Works’ industrial complex on the southern end of the Dead Sea.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/aronson-conveyor_satellite-2.jpg\" "\\"aronson-conveyor_satellite-2\\"")
<\/p>\nThe Dead Sea Works at dusk, framing the Salt Ponds; photograph via Israel Tour Guide<\/a>.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/dead-sea-works_1.jpg\" "\\"dead-sea-works_1\\"")
<\/p>\n\n
Evaporation ponds in the southern basin of the Dead Sea; image source<\/a>.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/dead-sea-works_4.jpg\" "\\"dead-sea-works_4\\"")
<\/p>\nThe Dead Sea Works in 1944; image source<\/a>; the history of the Dead Sea Works begins around 1920, when a Russian engineer by the name of Novomeysky realizes that the Dead Sea’s mineral wealth might be tapped cheaply through solar evaporation.\u00a0 By the Second World War, the Dead Sea Works (then known as the Palestine Potash Company) produced approximately half of all the potash used in British agriculture.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/dead-sea-works_3.jpg\" "\\"dead-sea-works_3\\"")
<\/p>\nThe Jordan River, historically the primary source of replenishment for the Dead Sea, spreads its watershed through the territory of Israel, Palestine, Jordan, Syria, Lebanon, and Egypt, producing an exceedingly difficult intersection of hydrological and political territory, making the implementation of watershed-level policy nearly impossible; map via<\/a> the United Nations Environmental Programme.<\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/jordan-basin.jpg\" "\\"jordan-basin\\"")
<\/p>\n“The Dead Sea #6”, via flickr user justavessel<\/a><\/div>\n![\"\"](\"http:\/\/m.ammoth.us\/blog\/wp-content\/uploads\/2010\/02\/dead-sea-works_2.jpg\" "\\"dead-sea-works_2\\"")
<\/p>\n